650Rider, xs650 hosted by XS650.com

What Happened to 650rider.com?

650 Rider went offline for about a month at the beginning of 2010. In order to save the technical information that was here, XS650.com acquired the site and brought it back online as a read-only archive. If you were a member of 650 Rider, you will need to re-register at XS650.com

Search 650Rider.com and XS650.com using Google!

        650Rider Menu
 Community  Information


xs650 > > The Vault > > The Vault > > your new old XS find. Newbies start here!


your new old XS find. Newbies start here!
    Forum Index -> The Vault
Author Message
jayel
650Rider Supporter
650Rider Supporter


Joined: Apr 16, 2006
Posts: 3417
Location: SE Iowa 1974 TX650A

PostPosted: April 1, 2009, 6:09 pm    Post subject: your new old XS find. Newbies start here!

stole this from a Honda site and changed it to read Yamaha 650 it still applys..........

“My XS650 won’t.........”


OK, you’re a Newb, you just found an old Yamaha twin, and you’re pretty sure you want to do this vintage bike thing.
Whether you’re evaluating a prospective purchase, or you’ve already got the bike home, here are six easy steps to get the info you need to make rational decisions about this project.
Don’t go off half-baked and just start tearing into or adjusting things - and don’t start firing half-baked questions at the folks on your favorite newsgroup (hopefully 650Rider.com).
You’ll waste their time as well as your own, and you’ll waste money - this stuff gets expensive, as you’ll soon find out.

First, disregard anything the Previous Owner might have told you. Probably all lies in the first place.
It would be great if the bike leapt to life and ran great first time you try, but it rarely happens that way in real life......

Get the Yamaha Manual

1) Change the Oil - Just do it, don’t even start the bike until you do it.
Examine the old oil carefully, look for color, metal shavings, bits of rubber, etc.
Smell it - does it smell of fuel??

Pull out the spark plugs and go here - this will indicate how the bike ran the last time it did run....
www.4secondsflat.com/p...chart.html


2) Battery - the root cause of so many apparently unrelated problems.
The ignitions on these old Yamahas runs totally off the battery.
They simply won’t start and run ok with a compromised battery.
Worse yet, these batteries are about half the size they need to be, so it doesn’t take much to hurt them. I’ve always held that I’d be glad to pack another 10 pounds on my bikes, as long as it was a bigger battery.
If your battery has been run completely dead more than 4-5 times, then it’s been hurt.
Brand new batteries can be bad right out of the box, so be aware of that - happened to me just last summer.
If it’s old, replace it.
If it looks weird, replace it.
If there’s any question at all, replace it.
And buy a battery charger.


3)Compression - probably the #1 cause of problems with Barn finds and unrestored bikes (once you get a new battery).......
These old bikes had pretty high compression, and most don’t retain it after years of inactivity - even low mileage bikes.
Beg, borrow, or steal the use of a compression gauge - only takes a minute to do.
Warm engine, throttle wide open, no choke. Take readings at both spark plug holes a couple of times.
If it won’t run, take the readings with a cold engine - generally only about 5 pounds or so less than a hot engine.
If the compression values are acceptable, resist any temptation to mess with the engine.

If the numbers are unsatisfactory, stop now, you have some serious problems. You are looking at a top end job, could cost you anywhere from $150-$300 or more, depending on what you find.
It is pointless to try and get the bike to run well, it’s not gonna happen, a waste of time and money.............
These are incredibly tough old engines - they will try and run for you no matter how bad they are, but don’t be fooled.
Examples of MINIMUM compression values before top end rebuild is indicated
under- 100 psi poor
100/125 psi good
125/150 psi excellent
both cylinders should be within 10% of each other


Fuel - A word on fuel.
Yamaha is clear in the 650 manual - the bike was designed around 95 octane fuel. Back in The Day, that was “regular” gas. It is reasonable to expect that were all designed around this octane level.
It’s hard to find gas like that today. I keep a couple of 5-gallon cans in my garage that have been treated with octane booster (on The Road, I do the best I can, like everyone).
Lots of folks will argue about this octane stuff, that’s fine. It’s your bike, after all, run whatever gas you please.
But I notice an easily perceptible increase in performance on my bikes when I run high-octane, they like it. So that’s the last word for me.
y tractor and snow blower like high octane, too !!!


4) Timing - Next in order of potential for trouble is the ignition timing.
First make sure all your components, points/coils/condensors/wires/caps are all ok.
Remember, this stuff is around 35-40 years old now, that’s not good for electrical stuff, it wasn’t designed with a 50 year service life.
Also be aware that condensors have a limited shelf life even if they’ve never been used.
Parts are widely available for most stuff, and aftermarket coils are available for cheap.
mikesXS.com

Armed with their Clymer’s manual, a lot of folks read “gap the points”, and happily proceed to gap both points, not realizing they probably just screwed up their timing even worse than it was.
Go to the articles at xs650temp.proboards.com/index.cgi? to get an idea of the correct timing procedure for these bikes. The procedure is very specific to the Yamaha Twins, and must be followed to the letter.


5) Carbs - The carbs and fuel system.
Check the condition inside your tank - if there’s rust, you need to do something about it.
Check the petcock - any leaks or sediment in there, does it work ok and deliver fuel to the carbs ok?? If the tank rusty, the petcock most likely needs help.
Finally, are the carbs clean?? Do they have fuel in the float bowls?
Is there any leaking?? If so, you need to fix that right away, it will destroy the new oil you just put in..........
Now find the article at xs650temp.proboards.com/index.cgi? about setting up 650 carbs - the info applies to all the CV carb Twins of the era.


6) Running Gear - This is safety-first stuff.
Tires - if they’re more than 4-5 years old, replace them. Don’t mess around, just replace them.

Brakes - make sure everything works quietly and smoothly.

Drive chain - make sure it’s in good shape. Grab the chain at the 3-o'clock position of the rear sprocket, pull it straight back. If it separates from the sprocket more than just a little, it’s suspect.
If you have the chain off, hold it by one end and try to extend it horizontally “against the grain”. If it sags like a rope, it’s bad.

Swingarm - with the bike on the center stand, grab the rear wheel at the 12-o’clock position and push hard side to side (rider left to rider right). If there is any play at all, the swingarm bushings are bad, and the bike is not safe to ride, depending on the severity.
It needs to be very tight.

Forks/shocks - not much can be said about Yamaha’s rear shocks of this era - they either work (sort of) or not. Usually it’s a matter of how much rust you can put up with, if they do work.
It would be prudent to drain and replace the fork oil. It’s an easy procedure, and will let you know if there are any leaks (in a short while). Many times on barn finds, there’s no oil at all in the forks. You can use regular fork oil, or you can use ATF, whatever strikes your fancy.


Finally - You’ve now made a pretty good effort to do this thing. If you’re still having problems, or just want to share your joy at success, now is the time to post your questions to the experts at 650Rider.com.
You’ll have accumulated much of the info they need to diagnose your situation, and performed many of the steps they would suggest in the first place.
There’s a dandy Search function at the site - use it, your problem has most likely been specifically addressed before.

_________________
all it takes is time and money -- Where are we going and why are we in this hand basket?
Back to top
Photo Gallery
oldbikenut
Full Member
Full Member


Joined: Feb 03, 2009
Posts: 367
Location: New Mexico

PostPosted: April 1, 2009, 6:26 pm    Post subject: Re: your new old XS find

Really great! Nice reference for new vintage bike owners!
Back to top
nj1639
Full Member
Full Member


Joined: Aug 22, 2007
Posts: 839
Location: Switzerland County, Indiana

PostPosted: April 1, 2009, 8:30 pm    Post subject: Re: your new old XS find

Agree totally.
_________________
"Go ahead, turn the damn power and water off, I'm ready!
'83 xs650sk
www.650rider.com/index...pic&t=5392
Back to top
bluebikerblan
Full Member
Full Member


Joined: Apr 18, 2007
Posts: 336
Location: Brigham City, Utah

PostPosted: April 1, 2009, 8:44 pm    Post subject: Re: your new old XS find

Great for the newbee. Good for us all. Should be required reading for folks about to buy their vintage "find". Especially that one....."that was running great when I put it away and probably only needs a new battery".

Thanks as usual Jayel. Blue

_________________
Biker Up & Buckle Down
Back to top
danno
Full Member
Full Member


Joined: Mar 04, 2006
Posts: 212

PostPosted: April 1, 2009, 9:03 pm    Post subject: Re: your new old XS find

Very generous use of your time and energy! Thank you for the "universal" information. Good stuff!
Back to top
weekendrider
Support Staff
Support Staff


Joined: Apr 20, 2007
Posts: 1284
Location: SW MO 2x83SK 79F 78E

PostPosted: April 1, 2009, 9:21 pm    Post subject: Re: your new old XS find

Nominated as a permanant or stickey post.
_________________
geocached @ N 37° 26.917', W 093 11.724, elev. 1148'
Back to top
yamaman
Support Staff
Support Staff


Joined: Jan 04, 2007
Posts: 1638
Location: Perth Western Australia

PostPosted: April 17, 2009, 2:56 pm    Post subject: Re: your new old XS find

Seconded
_________________
Its not enough to have an aim in life, you have to pull the trigger!
Back to top
Photo Gallery
XSDAD
Full Member
Full Member


Joined: Sep 03, 2008
Posts: 176

PostPosted: April 17, 2009, 3:34 pm    Post subject: Re: your new old XS find

Thirded
_________________
I like bike.
Back to top
 
    Forum Index -> The Vault All times are GMT - 5 Hours
Page 1 of 1


 
You can post new topics in this forum
You can reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum
You cannot attach files in this forum
You cannot download files in this forum


   


Check out the new Honda CB750 Forum at CB750.com! A site dedicated to the great Honda SOHC and DOHC CB750.

Check out the new Yamaha XS400 Forum at XS400.com!

Yamaha xs650

xs650, xs, 650, forum, links, chopper, custom, yamaha, parts, forum, info, information, bb, bulletin board, XS650
650Rider, Free Unrestricted xs650 forum, Personal photo albums, Post images in Forum, News columns, Daily blog, Links, Event calendar, Information for Yamaha XS650



Interactive software released under GNU GPL, Code Credits, Privacy Policy